1996 opel astra
1996 opel astra
1996 opel astra
1996 opel astra
More photos Opel Astra

1996 Opel Astra the car can't start problems

Report a Problem

Date:July 2, 2012, 6:30 pm
Name:Njabulo Ndlovu
Location:Zimbabwe, Bulawayo
Vehicle:Opel Astra
Year:1996
Modification:140S sedan
Problems:it has an electronic system problem can't get an original electronic module and as a result it can't start, have tried to use other modules similar but they are all not working. The original electronic module was manufactured by a company called dupec electronics, the part number is model A045-A, DELTA P/N 93592887

Suggest a Solution


September 18, 2012, 8:29 pm  from: Chiki
If you give more details I may be able to help. But I am will to bet my last dollar its not the ECU thats dead. Before you do anything in an Astra it is important to know what caused it not to start. First of all try to remember your last actions before the car started the problem. Is there anything you may have changed? For example plugs, some sensors etc. The ECU (if that is what you are referring to as the electronic module) rarely packs up. The most common procedure for Astra is as follows:

1. Check fuel pump (for pressure)and fuel filter usually clipped near rear wheel under boot
2. Check fuel relay
3. Check immobiliser (you can get it bypassed)
4. Check coil pack
5. Check HT leads
6. Check plugs expecially the one on your right if its oily The car wont start. Replace all with Resistor Plugs if its fuel injection. Remember your car will not start at ALL if you have wrong plugs. It may drive but jerks or start hissing uncontrollably. In fact if that happens you are sure the computer box is working and trying to read the errors.
7. Check airflow system or just clean the whole throttle body, oxygen sensors, airfilter [YES AIRFILTER] etc.
8. Check water temp sensor
9. Check crank sensor
10. Of course check that the timing belt is fitted properly. If its loose replace and have a mech set the timing.
11. AstraS heat up a lot never forget to check the oil and coolant.

I struggled for months when my Astra could'nt run only to remember that when it stopped starting I had put some OIL-burning plugs in. I removed them and put the correct set and the baby was quiet and driving like new again.

FINALLY, if all fails check the computer box for any obvious burn out or dry-joints. Or maybe water got inside. I have a spare 3-pin box which works on 160i. If you send me a picture of yours I may be able to help. But remember the steps you take can be the ones that cause the car not to start.

I hope among these tips you found somthing useful but remember:

1. JUST BECAUSE YOU PUT A NEW PART IT DOES NOT MEAN IT WORKS
2. ALWAYS GET A SECOND OR THIRD OPINION BEFORE YOU GET MAJOR PARTS
3. REFER TO THE MANUAL
Contact: show contact
October 16, 2012, 6:30 pm  from: david
If you can help me my opel astra jecks after 1hour open drive especial on hills I have been pulling petrol from the pipe of the petrol filter and pore it to the pump then it work to avoid that what I need to replace?
Contact: show contact
October 16, 2012, 6:33 pm  from: david
If you can help me my opel astra jecks after 1hour open drive especial on hills I have been pulling petrol from the pipe of the petrol filter and pore it to the pump then it work to avoid that what I need to replace?
Contact: show contact
October 16, 2013, 6:58 pm  from: alfonso
my kadett f died..car was off aswell as ignition. .battery connected the mechanic unpluged the module plug that sits against the cars body..now the car n every electric thing is dead..no dash lights n ive checked all fuses I can find..no luck! ! any help??? also the dupec A045 - A kadett/astra...
Contact: show contact
October 16, 2013, 6:59 pm  from: alfonso
my kadett f died..car was off aswell as ignition. .battery connected the mechanic unpluged the module plug that sits against the cars body..now the car n every electric thing is dead..no dash lights n ive checked all fuses I can find..no luck! ! any help??? also the dupec A045 - A kadett/astra...
Contact: show contact
February 23, 2015, 9:21 pm  from: edwin
I have 1998opel kadett 200ise it doesn't spugging new coil i don't know either the car has module i look allaround i don't got it plz i need help it just turning but not start udualy the engin cooling fan was turning when i swich on the car but now not turning the fuse is fine plz i need help to get start does 1998 opel kadett 200ise have a module can u tell me is located the cranck sander is ok what it could be a problem plz guys
Contact: show contact
April 12, 2017, 8:39 pm  from: Isaack
CHIKI you know yr story,I'm really impressed,astra is yr toy,u know how to play with it.keep up the good work.
Contact: show contact
January 4, 2018, 11:16 am  from: Vijaikumar
Sir I am in nilgiris tamilnadu India. My opel astra petrol car model 1998 last four weeks car cranking but didn't start and no spark .I can change new coil pack and new plug wire and cranksensor . what is the solution of my car . please reply me.
Contact: show contact

Suggest a Solution

 * - The field should be filled
* Your Name:
 Contact (e-mail, phone...):
* Comments:
Photos:


 


Updated on March 28, 2024